鎳基超合金Haynes 282在950°C之初期空氣中高溫氧化行為研究

The Study of Incipient Oxidation Behavior of Haynes 282 Ni-based Superalloy in Air at 950°C

陳廷秝(Ting-Li Chen) ； 藍貫哲(Kuan-Che Lan) ； 董曉明(Hsiao-Ming Tung)

《防蝕工程》 35卷1期 (2021/03) Pp. 12-20

https://doi.org/10.6376/JCCE.202103_35(1).0002

摘要

鎳基超合金Haynes 282為先進超超臨界（A-USC）燃煤發電系統的候選結構材料。本研究利用熱重分析儀（TGA）對Haynes 282進行950℃下24小時的增重行為分析，並利用箱型爐進行950℃高溫空氣中進行12至96小時之氧化，探討該溫度下的氧化動力學，其增重結果符合拋物線曲線。此外，使用X光繞射儀（XRD）探討282合金氧化層內的相組成及結晶結構。利用帶有特徵X光能譜分析儀（EDS）之場發射掃描式電子顯微鏡（FEG-SEM）對其氧化層進行表面微結構觀察與成份分析，並利用帶有EDS的聚焦離子束電子束掃瞄式顯微鏡（FIB-SEM）對初期高溫氧化試片進行截面觀察與成分分析。

關鍵字

鎳機超合金 ； 火力發電 ； 高溫氧化 ； 氧化層厚度

並列摘要

Haynes 282, a nickel-based superalloy, is a candidate structural material for advanced ultra-supercritical (AUSC) coal-fired power generation systems. In this study, the thermogravimetric analyzer (TGA) was used to analyze the weight gain behavior of Haynes 282 at 950°C for the exposure time of 24 hours, and a box furnace was used to perform the air oxidation test of Haynes 282 at 950°C from 12 to 96 hours. The studies of oxidation kinetics revealed that both results correspond with the parabolic curve. In addition, the crystal structure of oxide layer on the specimens of 282 alloy surface were characterized by X-ray diffraction (XRD). A field emission scanning electron microscope (FEG-SEM) with characteristic energy-dispersive X-ray spectroscopy (EDS) and the dual beam focused ion beam (FIB) system was used to observe the microstructure and composition analysis of the surface of the oxide layer.

並列關鍵字

Ni-based alloy ； Coal-fired power ； High temperature oxidation ； Scale thickness

參考文獻

Birks, S.,Roberts, S.,Leese, R.(2014).Advances in materials technology for fossil power plants.Advances in Materials Technology for Fossil Power Plants - Proceedings from the 7th International Conference.(Advances in Materials Technology for Fossil Power Plants - Proceedings from the 7th International Conference).

Jablonski, Paul D.(2012).Processing of advanced cast alloys for A-USC steam turbine applications.Jom.64(2),271-279.

Pérez-González, F. A.,Garza-Montes-de Oca, N. F.,Colás, R.(2014).High temperature oxidation of the Haynes 282© nickel-based superalloy.Oxidation of metals.82(3-4),145-161.

Birks, Neil,Meier, Gerald H.,Pettit, Frederick S.(2006).Introduction to the high temperature oxidation of metals.Cambridge, UK:Cambridge University Press.

Shin, Kyeong-Yong(2019).Effects of heat treatment on the microstructure evolution and the high-temperature tensile properties of Haynes 282 superalloy.Materials Science and Engineering: A.751,311-322.