利用超臨界水還原方法製備奈米金屬及奈米金屬氧化物粉體之研究

Synthesis of Metal and Metal Oxide Nanoparticles by Supercritical Water Reduction Method

呂信諺(Hsin-Yan Lu)

指導教授 ： 陳延平

國立臺灣大學/工學院/化學工程學研究所/碩士(2005年)

https://doi.org/10.6342/NTU.2005.10464

摘要

不同於超臨界水水熱結晶製備奈米金屬氧化物，本研究以超臨界水還原方法製備奈米金屬及金屬氧化物。本研究使用四種前驅物，分別為硫酸鐵，硫酸銅，硫酸銀及四氯化鉑，並以甲酸作為還原劑，合成奈米四氧化三鐵、奈米銅、奈米銀及奈米白金。本研究主要探討欲得到不同奈米金屬及奈米金屬氧化物所需還原劑之濃度，及所得產物之粒徑大小及其分佈。由各產物之TEM圖所測得之粒徑大小，奈米銅平均粒徑約為18奈米，奈米銀約為28奈米，奈米白金約為10奈米。除成功製備奈米金屬，本研究亦提出超臨界水還原反應方程式。

關鍵字

超臨界水 ； 水熱結晶 ； 米四氧化三鐵 ； 奈米銅 ； 奈米銀 ； 奈米白金

並列摘要

In this study, supercritical water reduction (SCWR) method was applied to prepare metal oxide and metal nanoparticles. Different from the supercritical water hydrothermal crystallization, reduction methods was used to obtain the nanoparticles. Four kinds of metal precursors, ferric sulfate, copper sulfate, and silver sulfate, were employed in this study to prepare Fe3O4, Cu, Ag, and Pt nanoparticles. The effect of reducing agent concentration was examined. TEM micrographs showed that average particle size of copper, silver, platinum are about 18nm, 28nm and 10nm, respectively. The reaction mechanism for supercritical water reduction was also proposed in this study.

並列關鍵字

supercritical water reduction ； hydrothermal crystallization ； Fe3O4 ； Cu ； Ag ； Pt ； nanoparticles

參考文獻

Adschiri, T., Kanazawa, K., Arai, K., Rapid and Continuous Hydrothermal Crystallization of Metal Oxide Particles in Supercritical Water. Journal of the American Ceramic Society. 1992(a), 75, 1019-1023

Adschiri, T., Kanazawa, K., Arai, K., Rapid and Continuous Hydrothermal Synthesis of Boehmite Particles in Subcritical and Supercritical Water. Journal of the American Ceramic Society. 1992(b), 75, 2615-2620

Adschiri, T., Hakuta, Y., Arai, K., Hydrothermal Synthesis of Metal Oxide Fine Particles at Supercritical Conditions. Industrial & Engineering Chemistry Research. 2000, 39, 4901-4907

Anno, Y., Maekawa, T., Tamaki, J., Asano, Y., Hayashi, K., Miura, N., Yamazoe, N., Zinc-oxide-based Semiconductor Sensors for Detecting Acetone and Capronaldehyde in the Vapour of Consommé Soup. Sensors and Actuators B. 1995, 24-25, 623-627

Aymonier, C., Schlotterbeck, U., Antonietti, L., Zacharias, P., Thomann, R., Tiller, J. C., Mecking, S., Hybrids of Silver Nanoparticles with Amphiphilic Hyperbranched Macromolecules Exhibiting Antimicrobial Properties. Chemical Communications. 2002, 3018–3019