抗反射層膜及稜鏡覆蓋物對Ⅲ-Ⅴ族太陽電池特性影響研究

Effects of Antireflection Coating and Prismatic Cover on Ⅲ-Ⅴ Solar Cell’s Performance

陳尚甫(Shang-Fu Chen)

指導教授 ： 廖森茂

中原大學/工學院/電子工程研究所/碩士(2005年)

https://doi.org/10.6840/cycu200500132

摘要

對太陽電池而言，元件表面入射光之反射率及吸光面積扮演相當重要的角色;因此在本論文當中首先利用模擬軟體設計太陽電池之氮化矽單層抗反射層膜及氧化鈦/氧化鋁雙層抗反射層膜，並將設計結果運用於太陽電池的製程上，並藉由電流電壓特性及頻譜響應量測探討氮化矽單層抗反射層膜及氧化鈦/氧化鋁雙層抗反射層膜對於太陽電池特性的影響;而另一方面，我們也將設計稜鏡型覆蓋物結構並運用此結構於磷化銦鎵/砷化鎵/鍺三接面太陽電池上，並深入研究稜鏡型覆蓋物結構對於太陽電池特性的影響，經由實驗結果顯示，其結構對於三接面太陽電池短路電流、最大輸出功率及轉換效率皆有提昇的現象。

關鍵字

太陽電池 ； 稜鏡型覆蓋物 ； 抗反射層膜

並列摘要

The reflectance and illuminated areas on the device surface that play an important role for the solar cells. Thus in this dissertation, we first utilize the simulation software to design the Si3N4 single-layer and TiO2/Al2O3 double-layer antireflection coatings and make use of the design result on the process of manufacturing solar cells. And we confer that the Si3N4 single-layer and TiO2/Al2O3 double-layer antireflection coatings on the solar cell’s performance by the current-voltage characteristic and spectral response measurement. On the other hand, we would like to design the prismatic cover structure to apply on the InGaP/GaAs/Ge triple-junction solar cells. We also confer the prismatic cover structure on the effects of solar cell’s characteristics. The result shows that the structure also can increase the short circuit current（Isc）, maximal output power（Pmax）and efficiency（EFF）of the solar cell.

並列關鍵字

prismatic cover ； solar cell ； antireflection coating

參考文獻

[1] D. M. Chapin, C. S. Fuller, and G. L. Pearson, “A New Silicon p-n junction Photocell for Converting Solar Radiation into Electrical Power,” J.appl. Phys., 25, 676 (1954).

[2] D. C. Raynolds, G. Leies, G. Leies, L. L. Antes, and R. E. Marburger, “Photovoltaic Effect in Cadmium Sulfide,” Phys. Rev., 96, 533 (1954).

[7] Prince, M. B., Proc. 8th E. C. Photovolt. Solar Energy Conf, Dordrech: Kluwer Academic Publ., 1988, p.1632.

[10] Coutts, T. J., and M. Yamaguchi, Current Topics in Photovoltaics, 3, T. J. Coutts, and J. D. Meakin, eds., New York: Academic Press, 1988, p.79.

[16] Hans Joachim Moller, Semiconductors for Solar Cells, P21~22, 1993.