在印尼亞齊省以稻稈應用於發電之可行性研究

Feasibility Study of Rice Straw Utilization for Power Generation in Aceh Province, Indonesia

尹蕙雅(Fithriani Iznita)

指導教授 ： 吳俊諆

國立中央大學/管理學院/國際環境永續發展碩士在職專班國際專班/碩士(2014年)

摘要

中文摘要
本文以印尼的亞齊省作為分析地點，評估以燃燒稻草當作發電功率來源的可行性以及對環境造成的影響。稻草是農民收割作物後的殘留物，傳統的處理方式為就地燃燒，然而此方法將會造成稻田損失，並不適當；此外，亞齊省內約有210個村莊位於偏遠地區，受到地理位置限制而沒有任何的電力資源；因此本研究將評估在亞齊省以燃燒稻草為發電動力來源的可行性，並分析該應用對環境的影響。
有幾項分析將應用在本研究中，例如稻草收集率的變化，並進行三種不同的案例提供概要的發電範圍，其次是以可避免的廢氣排放量與每年減少的碳排放量作為環境影響的評估方法。
假設稻草的產量從2013年至2020年呈線性成長，預估2020年將可生產2,769 kt，產量明顯大於2012年的1,968 kt。
利用假設案例粗略估算稻草作為燃料所需的產量，並依比例分配發電量，2012年的電廠建議容量約20 MW，占稻草的能源分配量不到10%；而2020年稻草作為燃料的分配量預估可上升至10%-30%，這些原本會浪費的資源可提供30 MW至90 MW的電廠容量。
預測結果顯示，亞齊省至2020年可將10%至30%的稻草應用於發電，發電量約294,56 GWh至883.67 GWh，可作為那些偏遠村莊的電力資源。在水稻的收穫季節中，適當的處理方式也顯示出稻田損失可降低至5.9%，而傳統的處理系統造成的損失約18.9%。進一步的評估是該稻草應用可避免的廢氣排放量，估計出的範圍約222,391 tCO2/year至667,174 tCO2/year；同時，亦測量出本項研究每年減少的碳排放量可達221,878 tCO2/year至 666,661 tCO2/year。
關鍵字：稻草、發電量、降低排放量、收集效率、印尼亞齊省

關鍵字

稻草 ； 發電量 ； 收集效率 ； 降低排放量 ； 印尼亞齊省

並列摘要

Abstract
The feasibility assessment for rice straw-based power plant project of different capacities and the environmental impact from the emission reduction are performed for agricultural residue conditions in Aceh province, Indonesia. Rice straw usually treated as the burnt-away residue after the harvesting crop by the farmer. The enormous amount of paddy losses by the traditional handling system also represents the improper treatment in agriculture yield and waste of residue resource in rice straw in Aceh. Moreover, about 210 villages in Aceh, which located in the remote area, lack of grid-connected service yet due to the geographical location. Conforming to the aforementioned, this research evaluates the availability of rice straw for power generation and the environmental impact based on the application of rice straw.
There are several assessments being considered in this study, such as the variation of rice residue collection percentage in three different scenario cases to provide a projection in electricity generation, followed by the avoided carbon emission reduction.
Projection assumes a linear increase of rice straw from the period of 2013 to 2020 and showed that there will be 2,769 kt of rice straw generation in 2020 which is much larger the amount of rice straw 1,968 kt in 2012.
The proposal case of electricity generation is made by scenario cases with the projection for the following years with the assumption of rice straw allocation amount for fuel. According to those allocation percentage, the rough estimation of the rice straw production resulted in 2012, the proposal capacity of power plant is about 20 MW. This amount is based the less than 10% of rice straw allocation for energy purpose in 2012. In 2020 with the assumption of rice straw allocated amount for fuel varies from 10% to 30%, then these waste resources can supply for the projected capacity of rice straw-based power plant from 30 MW to 90 MW.
The electricity generation will range from 180 to 539 GWh by utilizing from 10% to 30% of the total rice straw yield in 2020. The power generation amount is a quiet promising value to be utilized as the electricity resources for those remote villages. The proposing of the proper treatment of rice yield in the pre-harvesting season also indicated the decreasing in paddy losses, which can be reduced to 5.9% from the traditional handling of hand-collection system with the paddy losses, is about 18.9%. Further estimation also gave the range of avoided emission from this type of rice straw application, which estimated in the range of 222,391 tCO2/year to 667,174 tCO2/year.
Keywords: Rice straw, Power generation, Emission reduction, Collection efficiency of rice, Aceh province, Indonesia.

並列關鍵字

Rice straw ； Power generation ； Collection efficiency of rice ； Emission reduction ； Indonesia ； Aceh province

參考文獻

Bakos G.C., Tsioliaridou E., Potolias C., 2008, Technoeconomic assessment and strategic analysis of heat and power co-generation (CHP) from biomass in Greece, Biomass and Bioenergy 32, 558–67.

Bakker R.R., Jenkins B.M., Williams R.B., 2002, Fluidized bed combustion of leached rice straw, Energy and Fuels, 16, 356–65.

Bhattacharya S.C., Salam A.P., Runqing H., Somashekar H.I, Racelis D.A., Rathnasiri P.G., Yingyuad R., 2005, An assessment of the potential for non-plantation biomass resources in selected Asian countries for 2010, Biomass and Bioenergy, 29, 153–166.

Butler R.A, Laurance W.F, 2009, Is oil palm the next emerging threat to the Amazon? Tropical Conservation Science 2 (1), 1–10.

Delivand M.K., Barz M., Gheewala S.H, 2011, Logistics cost analysis of rice straw for biomass power generation in Thailand, Energy 36, 1435–1441.