- 期刊
由熱處理法製備導電性聚丙烯腈薄膜及其應用在電磁波干擾遮蔽
Preparation of Conductive Polyacrylonitrile Films via Heat Treatment for Electromagnetic Interference Shielding
摘要
本研究利用熱處理法將聚丙烯腈薄膜中的銀離子還原成銀形成金屬化導電性薄膜，經由四端子方法量測薄膜表面電阻之變化，還原後的薄膜，其表面電阻約為10^0~10^2Ω/cm^2左右，藉由電磁波遮蔽效果的測試結果在30-1500MHz下，其值可達30dB以上，可以吸收或反射掉99.9％電磁波。
並列摘要
The silver ions in the PAN metal chelate can be easily reduced to silver by heat treatment. The surface resistivity of these reduction films were measured according to the conventional four-terminal method and exhibited excellent surface resistivity around 10^0~10^2Ω/cm^2. The shielding effectiveness of interference of these reduction films can be reached above 30dB between 30-1500MHz. At this level, 99.9% extraneous radiation is either reflected or absorbed by these reduction films.
參考文獻
張良濤、顏志超(2009)。由熱處理法製備導電性聚乙烯醇薄膜及其性質之研究。明新學報。35(1)，63-73。
(Endrey,A.L. (1963). U.S. Pat. 3, 073,784.).
(Jpn. Kokai Tokkyo Koho JP 84 207, 938 and 86 211, 370.).
(Hendricks, R. W. (1962). U.S. Pat. 3, 056, 169.).
Auerbach, A.(1984).Method for increasing the conductivity of silver-doped polyimides.J. Electrochem. Soc..131,937.
延伸閱讀
- 張良濤、顏志超（2009）。由熱處理法製備導電性聚乙烯醇薄膜及其性質之研究。明新學報，35(1)，63-73。https://doi.org/10.29688/MHJ.200902.0007
- 李貴琪、游輝仁、張紘瑞（2012）。聚酯織物以膨潤處理方式經無電極鍍鎳對電磁波吸收效果之分析。華岡紡織期刊，19(2)，67-72。https://doi.org/10.29984/JHGT.201206.0003
- 邱永勝（2004）。熱處理對聚丙烯腈中空纖維膜滲透蒸發分離效能之影響〔碩士論文，中原大學〕。華藝線上圖書館。https://doi.org/10.6840/cycu200400207
- 周建成（2014）。熱處理程序對聚丙烯腈管狀薄膜應用於滲透蒸發對極性溶劑脫水之研究〔碩士論文，中原大學〕。華藝線上圖書館。https://doi.org/10.6840/cycu201400715
- Chung, Y. W. (1973). Heat conduction in polycrystalline metal films [master's thesis, The University of Hong Kong]. Airiti Library. https://www.airitilibrary.com/Article/Detail?DocID=U0029-1812201200010469