晶圓級構裝可調T型線圈式濾波器之研製

本論文提出以晶圓級構裝製程應用於5GHz到2.5GHz的可調T型線圈式濾波器電路設計。採用外接3組可變電容來達成可調範圍較寬的設計，此一設計擁有中心頻率可調、外部品質因子可補償、以及頻寬可調的特色。設計一個模擬的程序，其模擬結果顯示，通帶頻率內最大損耗為3.48dB，濾波器尺寸為2.55mm × 1.42mm。由於晶片內的可變電容可調範圍有所限制，模擬結果可調範圍從5GHz到4GHz達20%，中心頻率損耗為3.55dB~3.98dB。接著以實驗驗證，設計2.5GHz到1.25GHz的可調T型線圈式濾波器實驗，並利用20mil的Rogers Ro4003基板、表面黏著式陶瓷電容來進行實驗。反射損耗-15dB、比例頻寬5%下，可調範圍達50%，濾波器尺寸為16.4mm × 11.8mm，量測結果，中心損耗為1.7dB~2.66dB，此結果與模擬一致。

關鍵字

可調帶通濾波器； T型線圈模型；晶圓集構裝；集總元件濾波器；基板合成波導濾波器；變容二級體； LTE頻帶

並列摘要

This thesis propose a tunable filter with T-coil circuit design whose tuning range is from 5GHz to 2.5GHz on InFO-WLP (Integrated Fan-Out Wafer-Level-Packaging). There are three sets of varactors to get wider tuning range so that the center frequency and external quality factor and bandwidth can be suitably tuned. A systematic design procedure has been set up and demonstrate the tunable filters of 3.48 dB in a compact size of 2.55mm×1.42mm. Due to the limited range of varactor value, simulated results show a tuning range of 20% from 5GHz to 4GHz, with insertion loss 3.55dB~3.98dB at center frequency . For experimental validation, a tunable T-coil filter with tuning range from 2.5GHz to 1.25GHz is designed and fabricated in 20mil Ro4003 board and SMD MLCC Capacitors. According to FBW=5% and return loss=-15dB, tuning range is 50%; size is 16.4mm×11.8mm; the measurement result shows loss at center frequency is 1.7dB~2.66dB and in good agreement with the simulation results.

並列關鍵字

Tunable Bandpass filter ； T-coil model ； InFO-WLP ； Lumped filter ； Varactor diode ； SIW filter ； LTE band

參考文獻

[1] Y. Jin, X. Baraton, S. W. Yoon, Y. Lin, and P. C. Marimuthu, “Next generation eWLB (embedded Wafer Level BGA) packaging,” in Proc. Electron. EPTC, pp. 520–526 , Dec. 2010.

[2] C.C. Liu, S.-M. Chen, F.-W. Kuo, H.-N. Chen, E.-H. Yeh, C.-C. Hsieh, L.-H. Huang, M.-Y. Chiu, Y., J., T.-S.Lin, T.-J. Yeh, S.-Y. Hou, J.-P. Hung, J.-C. Lin, C.-P. Jou, C.-T. Wang, S.-P. Jeng Y. and D.C.H., "High-performance integrated fan-out wafer level packaging (InFO-WLP): Technology and system integration," IEEE International Electron Devices Meeting (IEDM), pp.14.1.1-14.1.4, 10-13 Dec. 2012

[5] C.-K. Shen, M.-H. Tsai, H.-N. Chen, C.-P. Jou, S. Liu, F.-L. Hsueh, and T.-L. Wu, " Design of On-Chip Microwave Filters in Integrated Fan-Out Wafer Level Packaging (InFO-WLP) Technology " , 2015 Asia-Pacific Symposium, APEMC ,26-29 May 2015,pp. 246 - 248

[6] Q. Y. Xiang , Q. Y. Feng , X. G. Huang and D. H. Jia "Electrical tunable microstrip LC bandpass filters with constant bandwidth", IEEE Trans. Microw. Theory Tech., vol. 61, no. 3, pp.1124 -1130 2013

[7] H.-J. Tsai, N.-W. Chen and S.-K. Jeng, "Center frequency and bandwidth controllable microstrip bandpass filter design using loop-shaped dual-mode resonator," IEEE Trans. Microw. Theory Tech., vol. 61, no. 10, pp. 3590-3600, Oct. 2013.

國際替代計量

晶圓級構裝可調T型線圈式濾波器之研製

全文下載

主題瀏覽